伴隨著因疫情影響而重新爆發了大基建浪潮，混凝土運輸成為當下炙手可熱的運輸工作之一，不僅帶動了混凝土攪拌車的銷量，也吸引了一大波人加入到基建運輸行業之中。下面為了更好的了解它，來對關于攪拌車部件的常見問題及處理了解吧。

With the re outbreak of the wave of large-scale infrastructure construction due to the impact of the epidemic, concrete transportation has become one of the hottest transportation tasks at present, not only driving the sales of concrete mixer trucks, but also attracting a large number of people to join the infrastructure transportation industry. Next, in order to better understand it, let's learn about the common problems and treatment of mixer truck parts.

一、混凝土攪拌車拖輪是干什么的？

1、 What is the tug of concrete mixer?

攪拌車拖輪是個軸承，用于把罐體支撐起來，與攪拌車是一體的，輔助攪拌。

The mixer trailer is a bearing, which is used to support the tank and is integrated with the mixer to assist mixing.

二、攪拌車拖輪是干什么的？

2、 What is the tug of the mixer?

一般不建議自己換，直接到售后點找專門的人員更換，而且使用的油需符合要求，不然對設備損害很大，使用壽命也會大大縮短，更換合理標號的液壓油。

Generally, it is not recommended to replace it by yourself. Go directly to the after-sales point to find a special person to replace it. The oil used must meet the requirements, otherwise the equipment will be greatly damaged and the service life will be greatly shortened. Replace the hydraulic oil with a reasonable grade.

三、混凝土攪拌車罐體填充率跟罐體傾角有什么關系？

3、 What is the relationship between the filling rate of the concrete mixer tank and the inclination of the tank?

目前攪拌車傾角在12度左右，填充率為百分之六十三左右，傾角不好測量，填充率也很難計算。目前銷售的攪拌車都以有用的攪拌容積為準。

At present, the inclination angle of the mixer truck is about 12 degrees, and the filling rate is about 63%. It is difficult to measure the inclination angle and calculate the filling rate. The mixer trucks sold at present are subject to the useful mixing volume.

四、混凝土攪拌車罐不轉，轉開了沒力而液壓油從郵箱加油口噴出來是什么原因？

4、 What is the reason why the concrete mixer tank does not rotate and the hydraulic oil is sprayed out from the oil filler of the mailbox?

液壓一個進一個回，進沒力可能是油泵封閉部分壞了。回油沖，可能是油泵封閉腳墊壞了。

The hydraulic pressure goes in and out one by one. It may be that the sealing part of the oil pump is broken. The oil return is flushed. It may be that the sealing foot pad of the oil pump is damaged.

五、攪拌車攪拌筒的轉速是多少？

5、 What is the speed of the mixing drum of the mixer truck?

進料時攪拌筒的轉速是：6---10轉/分；攪拌時攪拌筒的轉速：6--10轉/分。

The rotating speed of the mixing drum during feeding is 6-10 rpm; Speed of mixing drum during mixing: 6-10 rpm.

六、8--12方的混凝土攪拌車進料口到地面距離是多少？

6、 What is the distance from the feed port of 8-12 m3 concrete mixer truck to the ground?

一般8--12方的攪拌車整車高度大概在3.8米左右，進料口距離地面就有3.5米左右，具體的根據不同的車型來定。

Generally, the height of 8-12 square meters mixer truck is about 3.8 meters, and the distance between the feed inlet and the ground is about 3.5 meters, depending on different models.

七、攪拌車怎么清洗罐？

7、 How does the mixer clean the tank?

攪拌車配的水箱，每次卸完料后就應該將水放入罐內，在返回時攪拌行使，到攪拌站后再將水排出接料。罐體外表應該在水箱加水時即可順便清洗。當然也可以直接用水箱內的水清洗。如果水泥漿已經凝固，罐體內找專門的清罐，外表凝固用草酸刷洗就行了。

For the water tank equipped with the mixer truck, the water shall be put into the tank after unloading each time, and the water shall be mixed when returning, and then discharged to the mixing station to receive the materials. The surface of the tank should be cleaned when the water tank is filled with water. Of course, it can also be directly cleaned with water in the water tank. If the cement slurry has set, find a special cleaning tank in the tank, and brush the surface with oxalic acid.

此外作為駕駛者的您要隨時通過后視鏡注意觀察罐子是否在轉，把轉速盡量調慢，轉速過高，車輛容易擺動，雖然已經時刻謹慎小心了，但是依然還有不少意外事故的發生，所以安全駕駛很關鍵。

In addition, as a driver, you should always observe whether the can is rotating through the rear-view mirror, and adjust the speed as slow as possible. If the speed is too high, the vehicle is easy to swing. Although you have been careful at all times, there are still many accidents, so safe driving is very important. For more information.